Audited Supplier
2000GF-D
O&M Oversea
3 Years
Self-Starting Diesel Generator
Fixed
Four Stroke
Water Cooling
AC Three Phase
Speed
Land Use
Common Units, Standby Unit, Emergency Crew
Ordinary
AC Rotating Exciter
Jichai
40hq
2000GF-D
China
Product Description
HFO generator 1MW 2MW
INTRODUCTION:
Dual fuel engine design is based on CSI HFO well run four stroke low speed engines; Provide same output whether running on Dual fuel or Diesel/HFO; Switchover from Dual Fuel mode to Diesel/HFO smoothly in engine operating; Low NOx Emission; High pressure gas injection for every cylinder; Precise gas injection timing, reliable and safety operation; 80% Diesel/HFO converted by NG, about 60% Fuel cost saving;
2MW heavy oil Diesel engine GeneratorINTRODUCTION:
Dual fuel engine design is based on CSI HFO well run four stroke low speed engines; Provide same output whether running on Dual fuel or Diesel/HFO; Switchover from Dual Fuel mode to Diesel/HFO smoothly in engine operating; Low NOx Emission; High pressure gas injection for every cylinder; Precise gas injection timing, reliable and safety operation; 80% Diesel/HFO converted by NG, about 60% Fuel cost saving;
Dual Fuel Engine Parameter
Engine Type: CSI 6/8 cyl. Inline, Turbocharged, After cooled, Diesel ignition, Medium speed. ™ Cylinder Bore: 300/320mm ™ Stroke: 380mm ™ Output:1.0~2.5 MW in Diesel ; 1.0~2.5MW in DF; ™ Gas supply pressure: suggestion not less than 2 bar abs. ™ Conversion ratio: 70~80% Gas, 20~30%Diesel fuel (limited by available gas pressure.) ™ Gas supply methode : Pilot injection for every cylinder ™ Clean Emission: NOx reduce 65%
2MW heavy oil Diesel engine Generator
System Configuration
Diesel/Dual Fuel-Controller: DC 901-03 ™ Driver Module for Gas Admission Valves: MVC 30-B ™ Diesel-Actuator: Heinzmann E16 ™ Gas admission valves: MEGASOL 200/400 ™ Knock Control system: ARIADNE KC 01 ™ Load measuring unit: LMG 11-01 ™ Digital Governor Panel: ARGOS ™ Exhaust temperature measuring system: WAGO with thermocouples + CAN ™ Power Supply: 24 V, 2x20 A
2MW heavy oil Diesel engine Generator
Benefit of Dual Fuel Operation Generator in HFO Mode:
LHV of HFO about: 10200 kcal/kg Fuel comsumption in full load: 215g/kwh, 1kg HFO=4.65kwh Turbochargered single gas generator operation(in market): Heating Value of the Natural gas about 9200kcal/Nm³ Gas comsumption in full load: 0.3Nm³/kWh, 1Nm³ gas=3.3kWh 1.0MW generator operating in dual fuel mode: Fuel/gas comsumption ratio: 70~80% gas, 20~30% diesel. HFO price in market: 0.74USD/kg HFO Power fee: 0.16 USD/kWh Natural gas price in market: 0.35USD/Nm³ Gas Power fee: 0.10 USD/kWh Dual-fuel operation: 0.16x25%+ 0.10 x75%= 0.11 USD/kWh Dual-fuel operation generating cost is half as the engine operating in HFO Generator can operate in single HFO mode, it give much reliable in power supply even if the shortage of the natural gas suppling.
Emission of Dual Fuel The emission of dual fuel engine is better than diesel engine: 1. NOx reduce 65% than diesel engine 2. CO reduce 54% than diesel engine 3. CO2 reduce 31% than diesel engine 4. CHx reduce 58% than diesel engine
